by noseoil » Fri May 29, 2015 8:02 am
The job of the framing is to support the skin attached to it, too many people forget this simple rule of building (house, plane, boat, trailer). At work we do roof systems, we're a residential roof truss plant here in Tucson. I work as an estimator and deal with lots of different load case scenarios. A "standard" roof deck is made to withstand loads which are dead loads (static or just sitting there type loads, like roofing, pipes, insulation, plywood, etc) and live loads (loads like the wind in a thunderstorm, a large plumber walking around with his tools, etc). This is normally 2' on center for the trusses and 1/2" plywood (or more commonly now, OSB) for the deck. Expand the spacing & you need thicker plywood. Reduce the spacing of framing members and you need less thick material.
My trailer deck is 1/8" baltic birch top & bottom, with 3/4" poplar & 3/4" foam as the framework. I won't walk on this 1/8" skin, as it would likely hole & I would go right through to the ground. With the mattress in place, there won't be a problem since the mattress will help spread the loads across the panels & framework, & act as part of the support system for loads. I'll use 1/2" OSB for decking during the build, then remove the pieces after it's finished & ready to roll.
Sorry about the diatribe, but 2x4 framing just isn't necessary if spacing is smaller for a trailer floor. You can use 1X2 frame members 1' on center & 1/4" plywood for the deck IF you don't walk on it during the build. The bottom skin can be 1/8" if it is well sealed from the elements and glued in place properly. Tabs welded to your frame will be fine.