by 48Rob » Sun Feb 27, 2011 2:46 pm
Gpw,
You may already be aware, but running a fan to help speed the drying process can go wrong if there is too much air movement, resulting in the solvents drying too quickly.
What happens is the paint/varnish can skin over too fast, trapping solvents under that layer that needed to finish evaporating.
When it is just too much, the solvent bursts through the top layer leaving pinholes.
Dud,
I use plain ordinary oil based paint.
I prefer reasonable quality paint, but in an effort to save money usually check the paint stores for mis-tints.
You can get $50-$60 a gallon paint for $5-$10 bucks a gallon.
I mix it well (or have the paint store shake it) pour a quart or so into another container and then thin it down with mineral spirits, usually about 50/50.
The mix doesn't have to be an exact formula, as the consistency will change with temperature.
Thin enough so that it will penetrate easily, but not so thin it drips out of the brush before you can get it on the wood.
As gpw suggests, the first coat (and only the first coat) can be put on pretty heavy as it will really soak in deep, and you want it to do so.
After it dries (the first coat may take 2-3 days depending on temperature and humidity) lightly sand or scuff, or even use a wire brush (lightly) to rough up the surface for the next coat.
After the first coat is dry, you'll notice very hard shiny painted areas, and dull, dry lightly stained areas.
For the second coat, Use fresh full strength paint, and thin it just a bit, around 25% mineral spirits, to allow the mixture to penetrate deeply in any of the softwood areas.
The second mixture will soak into the dull areas, but not the hard shiny ones.
After the second coat is dry (1-2 days) scuff, sand, or otherwise rough up the surface again.
Apply full strength paint.
Allow to dry and then repeat 1-3 more times until there are no areas of wood that do not look like they are completely sealed.
After the final coats are dry, then you can use undercoating or some other product as extra insurance to protect all your hard work.
It should be noted that if you are sealing the bottom of your floor, it should be done before you put the floor on the trailer, as it is far easier to do on a workbench...
It should also be noted that if you don't seal the edges of the plywood, you might as well not bother sealing anything...
When you flip the wood over and bolt it down, you must use care to seal any breaks in your protective finish.
I prefer to drill the holes slightly oversize, blow the dust out, and then use a small brush to apply paint inside the hole.
I'll also put some sealer/caulk in the hole, and on the top and bottom so water can not get in.
And finally, it is always good to seal wood on both sides if possible.
If you're going to use vinyl flooring, the adhesive will serve as a good sealer.
All this is a lot of work, and many will poo poo the idea that it is needed.
It isn't if you're building a low dollar trailer you plan to use for a couple years then throw away, but if you want it to last a lifetime; it requires a little more effort.
I'm not experienced with epoxy, but several here on the board are, and from what I hear, it is a good alternative, though I can't answer any questions about cost or effort required.
Rob
Waiting for "someday" will leave you on your deathbed wondering why you didn't just rearrange your priorities and enjoy the time you had, instead of waiting for a "better" time to come along...